Експериментальне обґрунтування тимчасового гігієнічного регламенту 2-гідроксипропанової (молочної) кислоти в повітрі робочої зони

  • Автори: В.А. Туркіна, Г.В. Призиглей, О.І. Грушка
  • УДК: 613.632.4:547.472.3
  • DOI: 10.33273/2663-4570-2021-90-1-70-74
Завантажити прикріплення:

Львівський національний медичний університет імені Данила Галицького, м. Львів, Україна


РЕЗЮМЕ. Молочна (2-гідроксипропанова) кислота є важливим метаболічним компонентом живих організмів, а також широко використовується в різних галузях промисловості. Таке широке застосування у виробництві викликає необхідність регламентації її вмісту в повітрі робочої зони. Токсичні ефекти впливу молочної кислоти описані в літературі. Встановлено, що 2-гідроксипропанова кислота за критерієм гострої пероральної та інгаляційної токсичності відноситься до ІV класу небезпеки, викликає подразнення шкірних покровів, сильне ушкодження очей, не володіє шкірно-резорбтивною та сенсибілізуючою дією, не спричиняє репродуктивну та тератогенну токсичність.

Мета. Обґрунтування орієнтовно безпечного рівня впливу (ОБРВ) 2-гідроксипропанової (молочної) кислоти в повітрі робочої зони.

Матеріали та методи. Аналітичні, токсикологічні, статистичні.

Результати. За результатами проведених токсикологічних досліджень виявлено, що 2-гідроксипропанова кислота в умовах інгаляційного експерименту (інтраназальне моделювання) викликає як зміни стану нервової системи, так і впливає на клітинний склад бронхоальвеолярного лаважу експериментальних тварин. Отже, після однократного інтраназального введення Limir = Limаc, її можна віднести до речовин із неспецифічною подразнюючою дією. Встановлено, що поріг однократного інгаляційного впливу становить 20 мг/м3.

Висновок. За даними, отриманими в експерименті, і даними відносно параметрів токсичності та гігієнічними регламентами хімічних аналогів розраховано величину ОБРВ для 2-гідроксипропанової (молочної) кислоти в повітрі робочої зони, що становить 1,0 мг/м3, аерозоль.

Ключові слова: 2-гідроксипропанова кислота, молочна кислота, ОБРВ, повітря робочої зони.

Introduction. Lactic (2-hydroxypropanoic) acid is an organic acid that is an important intermediate metabolite of living organisms, the end product of lactic acid fermentation, a metabolic component and a component of blood and muscle tissue. At the same time, it is widely used in various industries, such as production of food, cosmetics, pharmaceuticals and chemicals. In addition, on the basis of 2-hydroxypropanoic acid a relatively new type of polymeric materials is created — that is a biodegradable plastic [1].

Worldwide demand for lactic acid is estimated at 130–150 thousand tons per year. This product is important to industrial manufacturing, its volume at the world market is estimated at more than 500,000 tons and is increasing rapidly. In the near future it is projected to grow to 20–30% [2].

All above-mentioned factors lead to an increase in the number of workers exposed to lactic acid in the production environment. At the same time, in Ukraine as of 2019, there is no legally approved occupational exposure standard for this chemical compound. Therefore, the development of an indicative safe exposure level (ISEL) of 2-hydroxypropanoic (lactic) acid in the workplace air is a priority.

The available literature presents rather complete data on the toxic effects of lactic acid [3, 4, 5, 6]. It was found that 2-hydroxypropanoic acid belongs to hazard level IV by the criterion of acute oral and inhalation toxicity. The median lethal doses of the compound (LD50) when administered orally are: for female rats — 3,200 mg/kg, for male rats — 3,800 mg/kg, for white mice — 4,875 mg/kg, for rabbits — > 5,000 mg/kg. The median lethal concentration of the compound LC50 (4 hours, rats) exceeds 7,940 mg/m3. The clinical picture of acute intoxication is characterized by lethargy, ataxia, respiratory disorders, piloerection, lacrimation, salivation, diarrhea. Percutaneous toxicity studies showed that LD50 exceeded 2,000 mg/kg. Lactic acid does not have a skin-resorptive effect. The compound causes irritation of the skin (severe erythema and edema); in an ex vivo experiment, namely with enucleated chicken eye, it causes severe corneal damage, so it is labelled: causes severe eye damage [3]. The compound does not stimulate sensitization of the body in case of contact with the skin; it does not cause reproductive toxicity or teratogenicity [6].

Aim of the Research. Substantiation of the indicative safe exposure level (ISEL) of 2- hydroxypropanoic (lactic) acid in the workplace air.

Methods and Materials. International nonproprietary name: lactic acid. Chemical name:

α-oxypropionic (2-hydroxypropanoic) acid. Synonyms: 2-Hydroxypropionic acid, DL- Lactic acid, Lactic acid [USP: JAN], Lactic acid, dl-, Propanoic acid, 2-hydroxy-, (RS)-2-Hydroxypropionsaeure, 1-Hydroxyethane-carboxylic acid, Acidum lacticum, Aethyliden- milchsaeure, alpha-Hydroxypropionic acid, Lactate, Lactic acid, Lactic acid (natural), Lactic acid USP, Lacticum acidum, Lactovagan, Milchsaeure, Milk acid, Ordinary lactic acid, Propanoic acid, 2-hydroxy-, Propel, Propionic acid, 2-hydroxy-, Racemic lactic acid. CAS № 50–21–5 — racemic mixture of L (+) and L (–); 79–33–4 — L (+) α-oxypropionic acid.

Empirical formula: C3H6O3. Structural formula:


The experimental work was performed on white outbred female rats aged 3–3.5 months and weighing 180–200 g which were kept in the vivarium of Danylo Halytsky Lviv National Medical University. Experimental animals received standard pelleted feed with unrestricted access to drinking water.

The investigational product was administered intranasally in doses corresponding to concentrations of 6 mg/m3, 20 mg/m3, 60 mg/m3. Clinical observations included: monitoring the intensity and nature of motor activity, skin condition, changes in respiration, food and water intake.

A study of the indicators of the state of the nervous system (behavioral reactions and summation-threshold index — STI) was also conducted [7]. The effect on the deep respiratory tract was assessed through citologic analysis of broncho-alveolar lavage (BAL) fluid after a single-dose intranasal instillation [8]. The fluid was obtained by double infusion of the lungs at the rate of 1 ml of saline per 25 g of body weight of the animal. BAL fluid samples were prepared to be analysed and stored by cooling. To calculate the number and quality of bronchial epithelial cells, BAL samples were centrifuged for 10 minutes at 2,000 rotations per minute, the supernatant fluid was poured out, and smears were made from the precipitate and stained according to Romanowski-Geimsa. 200 cells were counted in each smear in the process of microscope observation [9].

During animal studies, the principles of bioethics and legal regulations were followed as well as the requirements of the provisions of the European Convention for the Protection of Vertebrate Animals Used for Experimental and Other Scientific Purposes [10] and Procedure for Conducting Experiments on Animals by Research Institutions [11].

Results and Discussion. The correlation dependence equation was used to plan studies to establish the acute action threshold (Limac) of 2-hydroxypropanoic acid [12].

lg Limac = 0,76 lg LС50 — 1,62
lg Limac = 0,76 lg 7940 — 1,62
Limac = 21,99 мг/м

lg Limac = 0,62 lg LС50 — 1,08
lg Limac = 0,62 lg 7940 — 1,08
Lim ac = 21,7 мг/м

Geometric mean:
< Limac > = 21,8 мг/м

In order to find the acute action threshold (Limac) experimentally, lactic acid was administered intranasally in doses corresponding to concentrations of 6 mg/m3, 20 mg/m3, 60 mg/m3 . The results of the research prove that all tested concentrations of the preparation do not cause death of experimental animals in.

When animals are exposed to lactic acid at the concentration of 60 mg/m3, changes in the state of their nervous system are observed (Table 1).

When the compound was instilled at a concentration of 20 mg/m3, changes in the state of the nervous system were less pronounced and manifested in increased inhibition of the cerebral cortex (as evidenced by the nature of changes in behavioral responses) and nerve impulse transmission (STI change). The lowest tested concentration did not cause significant changes in the parameters under study.


Table 1

Indicators of the nervous system state of white rats after a single-dose inhalation of 2-hydroxypropanoic acid

Note: * — significant differences from other groups (р ≤ 0,05).


Intranasal administration of lactic acid to white rats at a concentration of 60 mg/m3 caused an increase in respiratory rate of experimental animals (165 ± 17,6 breaths / min vs. 122±16,1 breaths / min in control, p < 0.05). Simultaneously, there was an increase in the total number of cells in BAL with a decrease in the proportion of macrophages and an increase in the proportion of neutrophils (Table 2). A similar trend was observed when the drug was administered at a dose of 20 mg/m3, but the changes were insignificant compared to the control, except for the percentage of macrophages (insignificant compared to the control decrease by 13%). When the drug was instilled at a concentration of 6 mg/m3, the respiratory rate of rats did not differ from the control of reactions, no changes were detected on the part of the cells of the bronchopulmonary segment.

The results of the research prove that the threshold of a single-dose inhalation action is 20 mg/m3 in terms of macrophages percentage in BAL and horizontal activity in the open field test. The zone of acute action is 397 (hazard level IV). Therefore, since the compound caused simultaneous alterations of the functional state of both respiratory and nervous systems, i. e. the threshold concentrations in terms of general toxicity effects and irritant effect coincide (Limir = Lim ac), it can be attributed to the substances with non-specific irritant effect.


Table 2

Cellular composition of bronchoalveolar lavage after a single-dose intranasal instillation of 2-hydroxypropanoic acid to white rats

Note: * — significant differences from other groups (р ≤ 0,05).

The correlation regression formula was used to calculate ISEL [13, 14].

To calculate ISEL value the following formulas were used:

lg ISEL = 0,92*lg10(Limir) — 1,22 [13]
ISEL = 0,906 mg/m

lg ISEL = 0,844*lg(Limir) — 1,141 [14]
ISEL = 0,948 mg/m3
ISEL = 1,2 — 0,012*16,8 + lg(М) [13]
ISEL = 2,9 mg/m3

ISEL = 0,4 — 0,01*М + lg(М) [13]
ISEL = 1,5 mg/m3

The average calculated ISEL value of 2-hydroxypropanoic (lactic) acid in the workplace air is 1.38 mg/m3.

The recommended ISEL value of 2-hydroxypropanoic acid (lactic acid) in the workplace air is 1.0 mg/m3, aerosol. In making the calculation the following was considered: lactic acid toxicity parameters, the nature of its biological effect on the body, information on occupational exposure standards of carboxylic acids approved in other countries (Russian Federation, Belarus, Kazakhstan) (maximum permissible concentration (MPC) of citric acid — 1 mg/m3, succinic acid — 3 mg/m3), as well as MPC of 2-hydroxypropanoic acid for ambient air approved in the Russian Federation (0.1 mg/m3).

Conclusions. 1. 2-hydroxypropanoic (lactic) acid acute effect threshold coincides in terms of its general toxicity parameters and signs of irritant effect on the respiratory system and amounts to 20 mg/m3.

2. The recommended value of 2-hydroxypropanoic (lactic) acid indicative safe exposure level in the workplace is 1.0 mg/m3, aerosol.



  1. Samuylenko AYA, Grin' SA, Yeremets VI, Shinkarev SM, et al. Trends in the development of lactic acid production. Bulletin of Kazan Technological University. 2017; 1(20): 162–6.
  2. D-lactic acid: global market overview. Website: https://marketpublishers.ru/report/industry/chemicals_petrochemicals/d-molochnaya-kislota-obzor-mirovogo-rinka-2016-g.html.
  3. European Convention for the Protection of Vertebrate Animals used for Experimental and Other Scientific Purposes. Strasbourg, 18.III.1986. European Treaty Series No. 123. Website: www.conventions.coe.int/treaty/en/treaties/html/123.htm (accessed on 11 April 2005).
  4. CLH report Proposal for Harmonised Classification and Labelling Based on Regulation (EC) No 1272/2008 (CLP Regulation), Annex VI, Part 2 L-(+)-lactic acid; (2S)-2-hydroxypropanoic acid EC Number: 201-196-2 CAS Number: 79-33-4 Index Number: - Contact details for dossier submitter: BAuA Federal Institute for Occupational Safety and Health Federal Office for Chemicals Friedrich-Henkel-Weg 1-25 D-44149 Dortmund, Germany Version number: 3.0 (post ACC), February 2017.
  5. Regulation (EU) No 528/2012 concerning the making available on the market and use of biocidal products Evaluation of active substances Assessment Report L(+) Lactic acid Product-type 01 (Human hygiene) January 2016 Germany.
  6. Uribarri J, Oh M, Carroll H. D-lactic acidosis. Medicine. 1998; 77: 73–82.
  7. Metodicheskie rekomendatsii № 2166-80: ispolzovaniyu povedencheskih reaktsiy zhivotnyih v toksikologicheskih issledovaniyah dlya tseley gigienicheskogo normirovaniya [No 2166-80. Methodical recommendations on the use of behavioral reactions of animals in toxicological studies for hygienic rationing] (аpproved MH USSR 14.04.80). Kiev; 1980, 47.
  8. Meyer KC, Raghu G, Baughman RP, et al. An official American Thoracic Society clinical practice giudeline; the clinical utility of bronchoalveolar lavage cellular analysis in interstitial lung disease. J. Respir. Crit. Care Med. 2012; 185(9): 1004–14.
  9. Matchinin AA, Katelnikova AE, Kryshen KL. Specific techniques of bronchoalveolar lavage collecting from laboratory animals. Laboratory Animals for Science. 2019; 4. https://doi.org/10.29296/2618723X-2019-04-06.
  10. Poryadok provedennya naukovymy ustanovamy doslidiv, eksperymentiv na tvarynakh [The order of carrying out by scientific institutions of experiments, experiments on animals] Ofitsiynyy visnyk Ukrayiny: Ofits. vyd. №24. s. 82. (Normative document of the Ministry of Education, Science, Youth and Sports of Ukraine. Order of 01.03.2012 № 249).
  11. Belen'kiy ML. Elementy kolichestvennoy otsenki farmakologicheskogo effekta [Elements of a quantitative assessment of the pharmacological effect]. Riga: Publishing house of the Academy of Sciences of the Latvian SSR; 1959, 112 s.
  12. Metodicheskiye ukazaniya, № 1943-78: primeneniyu raschetnykh i ekspress-eksperimental'nykh metodov pri gigiyenicheskom normirovanii khimicheskikh soyedineniya v vode vodnykh ob"yektov [No 1943-78. Methodical instructions for the use of calculation and express experimental methods for hygienic standardization of chemical compounds in water of water bodies] (аpproved MH USSR 08.12.78). Moscow; 1979. 28 s.
  13. Metodicheskie ukazaniya № 4000–85: ustanovleniyе orientirovochnyih bezopasnyih urovney vozdeystviya vrednyih veschestv v vozduhe rabochey zonyi [No 4000–85. Methodical instructions for establishing approximate safe levels of exposure to harmful substances in the air of the working area] (аpproved MH USSR 04.11.85). Moscow; 1985. 34.
  14. Bidevkina MV. Improvement of the system of hygienic regulation of chemicals in the air of the working area on the basis of determining the nature of the toxic effect in a short-term experiment [dis] Dr. med. Sciences: 14.02.04.


Received 11.06.2020